Sublimation comes up often in conversation and rarely with the context attached. Here we lay out the basics in order, then work through the practical considerations.
Last reviewed on 2026-07-13. Where a claim depends on a specific study, the study is described rather than over-claimed.
In practice, lyophilization is slower and more energy intensive than simple drying. Cycle times can range from hours to several days depending on load, container, and formulation. Amorphous materials may require excipients that help preserve structure during freezing and drying. The method is widely used for biological materials, pharmaceuticals, and foods where heat drying would cause unacceptable change. Open questions remain about scaling cycles between laboratory and production equipment, and this gap affects technology transfer.
Lyophilization removes water by freezing a material and then lowering pressure so ice changes directly to vapor. The process relies on sublimation, the phase transition from solid to gas without an intermediate liquid state. Because the material remains frozen during primary drying, the structure often stays porous. This porous matrix can rehydrate quickly when water is added back. The low pressure also allows vapor to leave the solid matrix without boiling.
Quality control for lyophilized materials includes visual inspection, residual moisture measurement, and reconstitution testing. Cake appearance can reveal process problems such as collapse, shrinkage, or meltback, although appearance alone does not prove potency. Residual moisture is commonly measured by Karl Fischer titration or by loss on drying. Reconstitution time is checked because a slow or incomplete dissolve can indicate a change in pore structure. Stability studies track these attributes over time under defined temperature and humidity conditions.
Analytical methods for lyophilized solids must account for the low moisture content and the fragile cake. Karl Fischer titration is widely used for water content, while near-infrared spectroscopy can measure moisture non-destructively in sealed containers. X-ray diffraction and modulated differential scanning calorimetry help identify crystalline or amorphous phases. Residual solvent analysis may be needed if organic solvents were used during formulation. The combination of these methods supports batch release and long-term stability assessment.
Lyophilized products are typically stored as sealed solids in vials or syringes. Moisture ingress is a major concern because many dried cakes are hygroscopic and can lose stability when exposed to humid air. Storage temperature depends on the formulation; some products are kept refrigerated, while others are stable at room temperature. Container closure integrity and headspace moisture are often monitored. Light protection may also be required for some photosensitive materials.
| Property | Value | Notes |
|---|---|---|
| Common synonym | Freeze-drying | Same dehydration operation |
| Typical vacuum | 10-100 Pa | Pressure during primary drying |
| Primary drying temperature | -40 to -10 °C | Below collapse temperature for many formulations |
| Cycle duration | 12-72 hours | Varies with load, container, and formulation |
| Key phase change | Sublimation | Solid ice to water vapor |
Freeze-drying is distinct from simple evaporation and from spray drying. Evaporation removes water at temperatures above freezing, while spray drying rapidly dries droplets in a heated gas stream. Lyophilization avoids high temperatures, which can be useful for heat-sensitive materials such as proteins, vaccines, and some foods. The porous cake produced by sublimation dissolves or rehydrates more quickly than a dense dried mass. Not all materials tolerate freezing or the pH shifts that can occur as solutes concentrate during ice formation.
Lyophilization removes water from a frozen material by sublimation under reduced pressure. The process begins with freezing, which converts liquid water into ice and fixes the structure of the sample. After freezing, primary drying lowers pressure so ice changes directly to vapor without passing through a liquid phase. Secondary drying then removes bound water that remains after ice sublimation. The result is a dry, porous solid that often retains its original shape.
Storage stability depends on water content, oxygen exposure, and temperature. Lyophilized solids are hygroscopic and can absorb water if exposed to humid air. Vials are usually sealed under vacuum or inert gas with rubber stoppers and aluminum crimps. Storage temperatures range from room temperature to refrigerated or frozen conditions depending on the material. Stability studies track potency, moisture, and physical form over time. Accelerated conditions can reveal sensitivity but may not predict long-term behavior.
Analytical methods for lyophilized materials include X-ray diffraction for crystallinity, differential scanning calorimetry for thermal transitions, and scanning electron microscopy for pore morphology. Moisture sorption analysis shows how the cake responds to humidity. These methods help distinguish amorphous from crystalline states and detect phase changes. Open questions remain about how pore structure changes during long-term storage and how best to predict collapse under varied conditions. Comparisons across studies are complicated by differences in formulation, cycle, and storage history.
Lyophilization is a dehydration process that removes water from a frozen material by sublimation under low pressure. The material is first frozen to convert liquid water into ice. Next, the pressure is reduced below the triple point of water so that ice changes directly into vapor without passing through a liquid phase. This step is called primary drying. The result is a porous solid or cake that retains the original shape of the frozen solution.
After primary drying, secondary drying removes water that remains bound to the material. This stage raises the shelf temperature while maintaining low pressure, which encourages desorption of unfrozen water. Residual moisture can be reduced to a low percentage, improving stability for many products. The process parameters, including freezing rate, shelf temperature, and chamber pressure, influence the final pore structure and reconstitution behavior. Control of these variables helps prevent collapse or meltback during drying.
An earlier multicenter analysis of the randomized IDE study reported similar findings, with improved patient-reported outcomes relative to fusion. These improvements included greater reductions in disability as measured by the Oswestry Disability Index (ODI), a standard scale used to assess limitations in daily activities due to back pain. A separate long-term follow-up has shown that TOPS preserves near-normal motion and may reduce the risk of adjacent segment degeneration.
Aged mouse tissues exhibit globally increased malonylation, potentially due to elevated expression of acetyl-CoA carboxylase and reduced activity of the deacylase SIRT5, which depends on declining NAD+ levels. These findings suggest a role for histone malonylation in the epigenetic regulation of aging processes. In type 2 diabetes, lysine malonylation is significantly elevated in liver tissue, as shown in obese mouse models such as db/db and ob/ob mice. Many of the affected proteins are involved in glucose and lipid metabolism, and malonylation of glycolytic enzymes has been shown to suppress their activity, leading to reduced glycolytic flux. Six of the ten glycolytic enzymes are malonylated at sites regulated by the demalonylase SIRT5, which counteracts this inhibition and may serve as a therapeutic target, along with other yet unidentified enzymes that regulate malonylation. In osteoarthritis, SIRT5 expression decreases in cartilage during aging while lysine malonylation increases. In mice, the combination of Sirt5 deficiency and high-fat diet–induced obesity exacerbates joint degeneration, accompanied by widespread hypermalonylation of glycolytic enzymes and impaired chondrocyte metabolism. A rare missense mutation in human SIRT5 (F101L) found in familial osteoarthritis further confirms a direct link between hypermalonylation and osteoarthritis. In resting macrophages, glyceraldehyde-3-phosphate dehydrogenase (GAPDH) binds to inflammatory mRNAs such as TNFα and suppresses their translation.
=== Indian Ocean === As of 2022, India is one of five countries that produced 50% of the world fish bladder supply and 70% of its value. The Indian swim bladder trade dates back to the 1800s for isinglass production, and has been regulated by the Indian government under the Harmonized System since 2002. Increasing demand from East Asia has driven fishing of croakers in particular, fueling an auction market in the major fishing and export ports Chennai, Kolkata, Mumbai and Veraval. There is little domestic Indian demand for fish maw. Bangladesh has a developing fish maw trade in the Karnaphuli delta targeting the high-value maws of Johnius coitor (datina koral) and Pomadasys argenteus, and Indian salmon. Less valuable but still traded fish maw species include Pangasius hypophthalmus, Labeo rohita, Catla catla, Wallago attu, and Leptomelanosoma indicum.
==== Absorption ==== Pregabalin is absorbed from the intestines by an active transport process mediated via the large neutral amino acid transporter 1 (LAT1, SLC7A5), a transporter for amino acids such as L-leucine and L-phenylalanine. Few (less than 10 drugs) are known to be transported by this transporter. Unlike gabapentin, which is transported solely by the LAT1, pregabalin seems to be transported by the LAT1 and by other carriers as well. The LAT1 is easily saturable, so the pharmacokinetics of gabapentin are dose-dependent, with diminished bioavailability and delayed peak levels at higher doses. In contrast, this is not the case for pregabalin, which shows linear pharmacokinetics and no saturation of absorption. The oral bioavailability of pregabalin is greater than or equal to 90% across and beyond its entire clinical dose range (75 to 600 mg/day). Food does not significantly influence the oral bioavailability of pregabalin. Pregabalin is rapidly absorbed when administered on an empty stomach, with a Tmax (time to peak levels) of generally less than or equal to 1 hour at doses of 300 mg or less. Food has been found to substantially delay the absorption of pregabalin and to significantly reduce peak levels without affecting the bioavailability of the drug; Tmax values for pregabalin of 0.6 hours in a fasted state and 3.2 hours in a fed state (5-fold difference), and the Cmax is reduced by 25–31% in a fed versus fasted state.
Sources: en.wikipedia.org
=== Rediscovery of ancient treatments === Similar to the situation in malaria therapy, where successful treatments based on ancient recipes have been found, there has already been some success in finding and testing ancient drugs and other treatments that are effective against AMR bacteria.
The δ13C of the emu's diet is reflected in the δ13C of the calcite of its egg shell. Small stones are swallowed to assist in the grinding up and digestion of the plant material. Individual stones may weigh 45 g (1.6 oz) and the birds may have as much as 745 g (1.642 lb) in their gizzards at one time. They also eat charcoal, although the reason for this is unclear. Captive emus have been known to eat shards of glass, marbles, car keys, jewellery and nuts and bolts. Emus drink infrequently but ingest large amounts when the opportunity arises. They typically drink once a day, first inspecting the water body and surrounding area in groups before kneeling down at the edge to drink. They prefer being on firm ground while drinking, rather than on rocks or mud, but if they sense danger, they often stand rather than kneel. If not disturbed, they may drink continuously for ten minutes. Due to the scarcity of water sources, emus are sometimes forced to go without water for several days. In the wild, they often share water holes with other animals such as kangaroos; they are wary and tend to wait for the other animals to leave before drinking.
== Pathogenesis == The cells of adipose (fat) tissue synthesize hormones known as adipokines. In humans, dysfunction of adipose tissue, even in cases without obesity, has been associated with the development of insulin resistance, hypertension, systemic inflammation, and increased risk of blood clots (thrombosis). The inflammation produced by these hormones are thought to inflame adipose tissue, leading to the production of more adipokines and perpetuation of the cycle, and a constant low-level, pro-inflammatory state. Although it is suspected that a similar mechanism occurs in horses, further research is needed.
== 19th Century == 1848: Maria Mitchell became the first woman elected to the American Academy of Arts and Sciences; she had discovered a new comet the year before. 1850: Margaretta Morris and Maria Mitchell became the first women elected to the American Association for the Advancement of Science. Morris was a renowned entomologist who specialized in agricultural pests and water beetles, the latter of which was cited by Charles Darwin in his novel On the Origin of Species. 1853: Jane Colden was the only female biologist mentioned by Carl Linnaeus in his masterwork Species Plantarum. 1889: Mary Emilie Holmes became the first female Fellow of the Geological Society of America. 1889: Susan La Flesche Picotte became the first Native American woman to become a physician in the United States. 1893: Florence Bascom became the second woman to earn her Ph.D. in geology in the United States, and the first woman to receive a Ph.D. from Johns Hopkins University. Geologists consider her to be the "first woman geologist in this country [America]." 1896: Florence Bascom became the first woman to work for the United States Geological Survey.
=== Video === introduction to NMR and MRI Richard Ernst, NL – Developer of multidimensional NMR techniques Freeview video provided by the Vega Science Trust. 'An Interview with Kurt Wuthrich' Freeview video by the Vega Science Trust (Wüthrich was awarded a Nobel Prize in Chemistry in 2002 "for his development of nuclear magnetic resonance spectroscopy for determining the three-dimensional structure of biological macromolecules in solution"). The Nobel Prize Winner - Documentary about Richard R. Ernst by Lukas Schwarzenbacher and Susanne Schmid (Swiss German with English subtitles) Other Qian, C.; Pines, A.; Martin, R. W. (September 2007). "Off Magic Angle Spinning". Journal of Magnetic Resonance. 188 (1): 183–189. Bibcode:2007JMagR.188..183Q. doi:10.1016/j.jmr.2007.06.006. PMID 17638585. Spotlight on nuclear magnetic resonance: a timeless technique
Sources: en.wikipedia.org
Solvent assisted inlet ionization (SAII) is similar to matrix-assisted inlet ionization however the matrix is a solvent such as water, acetonitrile and methanol. This ionization technique is highly sensitive to small molecules, peptides and proteins. The analyte is dissolved in the solvent and can either be introduced to the heated inlet tube by a capillary column or directly injected into the inlet tube with a syringe or by pipetting. The capillary column is made of fused silica particles with one end submerged in the sample solvent and the other in the end of the heated inlet tube. The solvent flows through the capillary column without the use of a pump due to the pressure difference between ambient pressure and the vacuum. The temperature can vary in the inlet tube from 50 °C to 450 °C, with the lower temperature being used if the results obtained from a higher temperature are of good resolution. Solvent assisted inlet ionization can be coupled not only to liquid chromatography (LC) but also to nano LC.
The negative ΔG indicates that the reaction is exothermic (exergonic) and can occur spontaneously. The energy stored in NADH and FADH2 is used to generate additional ATP through an electron transport chain with oxygen and protons (hydrogen ions) as the "terminal electron acceptors". Most of the ATP produced by aerobic cellular respiration is made by oxidative phosphorylation. The energy released is used to create a chemiosmotic potential by pumping protons across a membrane. This potential is then used to drive ATP synthase and produce ATP from ADP and a phosphate group. Biology textbooks often state that 38 ATP molecules can be made per oxidized glucose molecule during cellular respiration (2 from glycolysis, 2 from the Krebs cycle, and about 34 from the electron transport system). However, this maximum yield is never quite reached because of losses due to leaky membranes as well as the cost of moving pyruvate and ADP into the mitochondrial matrix, and current estimates range around 29 to 30 ATP per glucose.
Keegan, Sarah; Cortens, John P; Beavis, Ronald C; Fenyö, David (2016). "g2pDB: A Database Mapping Protein Post-Translational Modifications to Genomic Coordinates". Journal of Proteome Research. 15 (3): 983–990. doi:10.1021/acs.jproteome.5b01018. ISSN 1535-3893. PMID 26842767. McAfee, Alison; Harpur, Brock A.; Michaud, Sarah; Beavis, Ronald C.; Kent, Clement F.; Zayed, Amro; Foster, Leonard J. (2016). "Toward an Upgraded Honey Bee (Apis melliferaL.) Genome Annotation Using Proteogenomics". Journal of Proteome Research. 15 (2): 411–421. doi:10.1021/acs.jproteome.5b00589. ISSN 1535-3893. PMID 26718741. Fenyö, David; Beavis, Ronald C. (2015). "Selenocysteine: Wherefore Art Thou?". Journal of Proteome Research. 15 (2): 677–678. doi:10.1021/acs.jproteome.5b01028. ISSN 1535-3893. PMID 26680273. Liu, Fei; Koval, Michael; Ranganathan, Shoba; Fanayan, Susan; Hancock, William S.; Lundberg, Emma K.; Beavis, Ronald C.; Lane, Lydie; Duek, Paula; McQuade, Leon; Kelleher, Neil L.; Baker, Mark S. (2016). "Systems Proteomics View of the Endogenous Human Claudin Protein Family". Journal of Proteome Research. 15 (2): 339–359. doi:10.1021/acs.jproteome.5b00769. ISSN 1535-3893. PMC 4777318. PMID 26680015. Yan, Julia Fangfei; Kim, Hoguen; Jeong, Seul-Ki; Lee, Hyoung-Joo; Sethi, Manveen K.; Lee, Ling Y.; Beavis, Ronald C.; Im, Hogune; Snyder, Michael P.; Hofree, Matan; Ideker, Trey; Wu, Shiaw-lin; Paik, Young-Ki; Fanayan, Susan; Hancock, William S. (2015). "Integrated Proteomic and Genomic Analysis of Gastric Cancer Patient Tissues". Journal of Proteome Research. 14 (12): 4995–5006.
Calcitriol also reduces calcium loss to urine. Per the diagram, calcitriol suppresses the parathyroid hormone gene, thus creating a negative feedback loop that combines to tightly maintain plasma calcium in a normal range of 2.1-2.6 mmol/L for total calcium and 1.1-1.3 mmol/L for ionized calcium. However, there are also vitamin D receptors in bone cells, so that with serum vitamin D in great excess, osteoclastic bone resorption is promoted regardless of PTH, resulting in hypercalcemia and its symptomology.
Sources: en.wikipedia.org
Primary drying removes ice by sublimation under vacuum. Secondary drying removes water that is bound to the material, often by warming the product after most ice has left. Both stages occur below temperatures that would cause unwanted melting.
Sublimation requires the solvent to remain solid so vapor leaves without passing through a liquid phase. If the product melts, the porous structure can collapse and drying becomes uneven. Maintaining frozen conditions preserves the intended physical form.
No, freeze-drying is a dehydration method, not a sterilization step. It can reduce water activity and limit microbial growth during storage, but it does not reliably kill microbes or remove endotoxins. Sterility must come from separate validated processes.
Most lyophilized products are stored in sealed containers at controlled temperature and humidity. Some require refrigeration, while others are stable at room temperature. Protection from light and moisture is often necessary.